AUTHORIZED DEALER
SYNZILLA.com LLC
Michael Mathe
Save Time. Order Online.
Two Ways to Save

AMSOIL TECH BLOG

02/01/2015

AMSOIL Signature Series Synthetic Motor Oil New 700-Hour Limit Provides Clarity for Those Operating Vehicles That Idle Excessively

Oftentimes we talk about how long motor oil can be used - the expected service life - before it needs to be changed. Service life is most frequently described in miles and can be greatly affacted by a vehicle's operating conditions, which is why AMSOIL has provided definitions for normal and severe service.

For our Signature Series Products, AMSOIL defines severe service as primarily short trips (less than 10 miles [16 km]); turbo/supercharged engines; commercial or fleet vehicles; excessive idling; first-time use of AMSOIL motor oil in a vehicle with more than 100,000 miles; frequent towing, hauling, plowing, or driving in dusty conditions. Most of those conditions are straightforward. "Excessive idling," however, can be difficult to define. To add clarity, AMSOIL is now adding a 700-hour interval under both normal and severe service conditions.

AMSOIL created the graph below to help illustrate the importance of the hours interval by highlighting some examples. The graph shows the hours of engine operation, or idle time, versus the miles driven for a drain interval. The colored lines represent average speeds of a vehicle in four different scenarios. The blue line represents an average speed for a New York City taxi, which according to the EPA is only 7.1 mph. Even though the taxis there don't move very fast, their engines are operating nearly continuously, which means that the oil is being stressed for a large amount of time. If you follow the blue line in the graph, you can see that after 700 hours they have only traveled 5,000 miles. And according to the updated AMSOIL recommendation, these cabs should change their oil unless oil analysis says they can go longer.

During testing, we found that taxis running in Las Vegas average a consistent 14.6 mph. Even though the vehicles are not always moving, the engines stay on just to keep the air conditioners running. Following the orange line in the graph shows that these vehicles can accumulate a little more than 10,000 miles in 700 hours. That's the same amount of time as a NYC taxi, but they can go twice as long in terms of miles. This is a clear example of how the hours interval can significantly impact the amount of miles achieved in a drain interval.

The EPA city driving cycle is used to estimate the city fuel economy numbers we are familiar with seeing advertised on vehicles. It has an average speed of 21.2 mph, and it is a good representation of short-trip or stop-and-go driving seen in cities without major congestion. Vehicles primarily used in this capacity fall into severe service, so the mileage cutoff would be at 15,000 before the next oil change, which happens to correspond nicely with the 700-hour mark. Now if speeds are slightly above 21.2 mph, but the driving conditions fall into severe service (turbocharged, dusty, towing, plowing, etc.), then the drain interval will be limited by 15,000 miles before it reaches 700 hours.

Finally, the EPA highway cycle is shown in green, averaging 48.3 mph. This is mostly highway driving, and even after 25,000 miles the engine operating time is only slightly over 500 hours. Therefore, drain intervals will be set by 25,000 miles, and the hours don't even come into play.

AMSOIL Signature Series Synthetic Motor Oil represents the pinnacle of oil formulation, but all motor oils eventually break down. For many applications, especially personal-use vehicles, the average speed is high enough that the hours of engine operation are not a concern. However, for the high idle-time applications, such as those common to fleets, logging the amount of time the engine operates is important. Published, AMSOIL Magazine 02/15.

AMSOIL Signature Series Synthetic Oil 700-Hour Graph

AMSOIL Signature Series Synthetic Motor Oil New 700-Hour Limit Provides Clarity for Those Operating Vehicles That Idle Excessively.

SYNZILLA.com LLC is one of the largest and fastest growing Dealers of AMSOIL Synthetic Lubricants and is now expanding into your area. If you are a business owner or an individual with several vehicles, AMSOIL has several options available that may allow you to purchase AMSOIL Products at wholesale prices. We can show you how to save money and extend equipment life with AMSOIL Synthetic Motor Oils, Lubricants, Filters and Fuel Additives. Please visit the AMSOIL Online Store for more information about AMSOIL Products..

SAVE APPROXIMATELY 25% ON EVERY ORDER
Register as an AMSOIL Preferred Customer and save approximately 
25% on all AMSOIL products.
- FREE subscription to AMSOIL Magazine
- Premium protection and performance for all of your vehicles and equipment

- Access to the entire AMSOIL product line at wholesale prices

POPULAR LINKS